Force Outboard

I have a 1996 120 force outboard that i am trying to get ready, has been sitting for two years?

I started it finally after numerous tries and it now turns over but is shaky, smokes a good amount, and shuts itself off after few minutes of running. It only has 70 hours on it and has been winterized every year w/o probs, I'm guessing it just needs to be broken back in since its been sitting, also gas has been in the tank for two years almost (filled when winterized in 11/05) and that may be an issue as well. Also I had new plugs and a new battery installed this year. When I started it after it had stalled itself out, I gave it alittle throttle and got no response. Full throttle it made a loud clanking noise so I immediately put it back to neutral. I'm stumped on this, any help would be great. Thanks in advance!!

well if it was winterized and it was not done right the carbs need to be removed and cleaned out and gone through also the fuel filter(s) need to be replaced also the fuel lines need to be checked they might be rotten and collapsed
you also need new gas gas now days even when winterized goes bad after a few months
after all this is done the motor needs to be ran in a tank or in the water so it can be ran at a high rpm for break in and allowed to get everything cleaned out

Force Chrysler Outboard 1987 1994 85 125 HP Power Tilt Trim Cylinder FS654381
Force Chrysler Outboard 1987 1994 85 125 HP Power Tilt Trim Cylinder FS654381
$100.00
Time Remaining: 2h 38m
Buy It Now for only: $100.00

Force Outboard Power Trim Tilt Cylinder and Bracket 85 150 HP 1987 1994
Force Outboard Power Trim Tilt Cylinder and Bracket 85 150 HP 1987 1994
$150.00
Time Remaining: 2h 48m
Buy It Now for only: $150.00

Force Outboard 85 150 HP 1987 1994 Power Trim Tilt Cylinder FS654381 818055A 3
Force Outboard 85 150 HP 1987 1994 Power Trim Tilt Cylinder FS654381 818055A 3
$300.00
Time Remaining: 2h 54m
Buy It Now for only: $300.00

Force Chrysler Outboard 1987 1994 85 125 HP Power Trim Cylinder FS654381
Force Chrysler Outboard 1987 1994 85 125 HP Power Trim Cylinder FS654381
$100.00
Time Remaining: 2h 57m
Buy It Now for only: $100.00

TEE FITTING 17607 MERCURY FORCE MARINER 1987 1993 50 100 115HP OUTBOARD BOAT
TEE FITTING 17607 MERCURY FORCE MARINER 1987 1993 50 100 115HP OUTBOARD BOAT
$16.50
Time Remaining: 3h 19m
Buy It Now for only: $16.50

Drive Shaft Bearing Mercury Mariner Force Outboard Lower Units 31 77420A 1
Drive Shaft Bearing Mercury Mariner Force Outboard Lower Units 31 77420A 1
$22.74
Time Remaining: 3h 39m
Buy It Now for only: $22.74

PROPELLER FORCE OUTBOARD 10 1 8X15 H11015 W HUB 11 TURNING POINT 941 966 4320
PROPELLER FORCE OUTBOARD 10 1 8X15 H11015 W HUB 11 TURNING POINT 941 966 4320
$104.95
Time Remaining: 3h 40m
Buy It Now for only: $104.95

NEW Starter Mercury Force Outboard Marine 5551 MOT4001 50 514955
NEW Starter Mercury Force Outboard Marine 5551 MOT4001 50 514955
$81.93
Time Remaining: 4h 37m
Buy It Now for only: $81.93

Used Mercury Force Outboard Boat Motor Propeller Shaft 44 819284A3 FA707098
Used Mercury Force Outboard Boat Motor Propeller Shaft 44 819284A3 FA707098
$99.99
Time Remaining: 4h 56m
Buy It Now for only: $99.99

Used Mercury Force Outboard Boat Motor Propeller Shaft 44 819284A3 FA707098
Used Mercury Force Outboard Boat Motor Propeller Shaft 44 819284A3 FA707098
$79.99
Time Remaining: 4h 58m
Buy It Now for only: $79.99

NEW Chrysler Force Outboard White Vent Escutcheon Trim Outlet 85189 2
NEW Chrysler Force Outboard White Vent Escutcheon Trim Outlet 85189 2
$8.99
Time Remaining: 5h 18m
Buy It Now for only: $8.99

NEW Chrysler Force Outboard Turnbuckle Nuts 901704
NEW Chrysler Force Outboard Turnbuckle Nuts 901704
$5.99
Time Remaining: 5h 22m
Buy It Now for only: $5.99

FORCE OUTBOARD MOTOR STARTER 125HP
FORCE OUTBOARD MOTOR STARTER 125HP
$30.00
Time Remaining: 5h 24m

Force Chrysler outboard F15177 Starter Armature 75 85 90 120 125 150 hp NIB Oem
Force Chrysler outboard F15177 Starter Armature 75 85 90 120 125 150 hp NIB Oem
$85.00
Time Remaining: 5h 26m
Buy It Now for only: $85.00

1995 90 HP Force Outboard with trim tilt 1 bad piston Complete motor
1995 90 HP Force Outboard with trim tilt 1 bad piston Complete motor
$400.00
Time Remaining: 5h 44m

Starter Mercury Force Outboard Marine 50 514955 50 514955 1 50514955 505149551
Starter Mercury Force Outboard Marine 50 514955 50 514955 1 50514955 505149551
$81.93
Time Remaining: 5h 57m
Buy It Now for only: $81.93

FORCE TRIGGER ASSEMBLY F653029 1 1989 1994 85 90HP OUTBOARD MOTOR 757  1
FORCE TRIGGER ASSEMBLY F653029 1 1989 1994 85 90HP OUTBOARD MOTOR 757 1
$57.99
Time Remaining: 6h 6m
Buy It Now for only: $57.99

1989 1991 50 150hp Mercury Force Chrysler Outboard Ignition Coil
1989 1991 50 150hp Mercury Force Chrysler Outboard Ignition Coil
$24.99
Time Remaining: 6h 8m
Buy It Now for only: $24.99

Sierra power tilt and trim motor for a 1987 force 125 hp
Sierra power tilt and trim motor for a 1987 force 125 hp
$175.00
Time Remaining: 6h 10m

BLUE CD MODULE f685301 MERCURY FORCE 1988 1994 50 150HP OUTBOARD 1 657
BLUE CD MODULE f685301 MERCURY FORCE 1988 1994 50 150HP OUTBOARD 1 657
$53.99
Time Remaining: 6h 12m
Buy It Now for only: $53.99

FK1057 Gear Housing Seal Kit for Chrysler Force Sears Outboards 35 4 5hp
FK1057 Gear Housing Seal Kit for Chrysler Force Sears Outboards 35 4 5hp
$39.99
Time Remaining: 6h 24m
Buy It Now for only: $39.99

10 677551 Screw for Mercury Mariner Force Outboard Motors
10 677551 Screw for Mercury Mariner Force Outboard Motors
$4.99
Time Remaining: 7h 15m
Buy It Now for only: $4.99

Switch Box for Chrysler Force Outboard 85 125 HP 86 88 CDI 116 3301
Switch Box for Chrysler Force Outboard 85 125 HP 86 88 CDI 116 3301
$309.95
Time Remaining: 7h 47m
Buy It Now for only: $309.95

Switch Box for Chrysler Force Outboard 50 HP 84 87 F658475 116 8475
Switch Box for Chrysler Force Outboard 50 HP 84 87 F658475 116 8475
$239.95
Time Remaining: 7h 47m
Buy It Now for only: $239.95

New Starter Force Marine 507 508 50 HP 50HP Outboard Motor 1992
New Starter Force Marine 507 508 50 HP 50HP Outboard Motor 1992
$69.88
Time Remaining: 8h 8m
Buy It Now for only: $69.88

1990 Bayliner L Drive Force 90hp Engine Motor Cylinder Head Cover Outboard Used
1990 Bayliner L Drive Force 90hp Engine Motor Cylinder Head Cover Outboard Used
$99.99
Time Remaining: 8h 14m
Buy It Now for only: $99.99

CHRYSLER FORCE OUTBOARD SERVICE MANUALS on cd
CHRYSLER FORCE OUTBOARD SERVICE MANUALS on cd
$11.99
Time Remaining: 8h 20m
Buy It Now for only: $11.99

USED FORCE OUTBOARD TRIM AND TILT RELAY 87 803632T FROM 1991 35 HP
USED FORCE OUTBOARD TRIM AND TILT RELAY 87 803632T FROM 1991 35 HP
$11.00
Time Remaining: 9h 7m
Buy It Now for only: $11.00

STARTER ASSY 819085 MERCURY FORCE 1989 1999 70 150HP OUTBOARD BOAT 656
STARTER ASSY 819085 MERCURY FORCE 1989 1999 70 150HP OUTBOARD BOAT 656
$84.98
Time Remaining: 9h 15m
Buy It Now for only: $84.98

NEW STARTER MERCURY FORCE OUTBOARD 120 HP 120HP 120XR 120XR2 SPORT JET 1995 2000
NEW STARTER MERCURY FORCE OUTBOARD 120 HP 120HP 120XR 120XR2 SPORT JET 1995 2000
$99.80
Time Remaining: 9h 43m
Buy It Now for only: $99.80

Spacer Plate 817788A3 Mercury Force Boat Outboard Motor Engine Part
Spacer Plate 817788A3 Mercury Force Boat Outboard Motor Engine Part
$46.93
Time Remaining: 9h 44m
Buy It Now for only: $46.93

1989 1994 FRONT COVER FK719135 FORCE 90 150HP OUTBOARD BOAT MOTOR 757
1989 1994 FRONT COVER FK719135 FORCE 90 150HP OUTBOARD BOAT MOTOR 757
$74.98
Time Remaining: 9h 44m
Buy It Now for only: $74.98

New Thermostat for Force Outboards 25 35 40 50 HP 18 3556 Replaces F97068 2
New Thermostat for Force Outboards 25 35 40 50 HP 18 3556 Replaces F97068 2
$18.49
Time Remaining: 10h
Buy It Now for only: $18.49

Lower Unit Gearcase Seal Kit Force Outboard 75 120 HP 18 2626 Rplcs 26 43035A4
Lower Unit Gearcase Seal Kit Force Outboard 75 120 HP 18 2626 Rplcs 26 43035A4
$45.49
Time Remaining: 10h 5m
Buy It Now for only: $45.49

SkegShield Skeg Gaurd Mercury Yamaha Honda Tohatsu Nissan Force Outboard
SkegShield Skeg Gaurd Mercury Yamaha Honda Tohatsu Nissan Force Outboard
$119.95
Time Remaining: 10h 9m
Buy It Now for only: $119.95

Arco Chrysler Force Outboard Starter 5393 50853869T
Arco Chrysler Force Outboard Starter 5393 50853869T
$154.01
Time Remaining: 10h 16m
Buy It Now for only: $154.01

TOP CARBURETOR 9672A 4 MERCURY FORCE 1990 1991 135 150 175 200HP OUTBOARD MOTOR
TOP CARBURETOR 9672A 4 MERCURY FORCE 1990 1991 135 150 175 200HP OUTBOARD MOTOR
$51.73
Time Remaining: 10h 28m
Buy It Now for only: $51.73

FORCE OUTBOARD STARTER 50 F607955 1 NEW OEM PART NLA PART 60 HP 1984 85
FORCE OUTBOARD STARTER 50 F607955 1 NEW OEM PART NLA PART 60 HP 1984 85
$225.00
Time Remaining: 10h 30m
Buy It Now for only: $225.00

Mercury Mariner Force outboard Quicksilver 99328A 1 Froward Gear Tapered Bearing
Mercury Mariner Force outboard Quicksilver 99328A 1 Froward Gear Tapered Bearing
$30.00
Time Remaining: 10h 30m
Buy It Now for only: $30.00

1990 Bayliner L Drive Force 90hp Engine Motor Head Cylinder Outboard Bolts Lot
1990 Bayliner L Drive Force 90hp Engine Motor Head Cylinder Outboard Bolts Lot
$29.99
Time Remaining: 10h 36m
Buy It Now for only: $29.99

Prop for Force Outboard Motors PNs P694  48 FP694
Prop for Force Outboard Motors PNs P694 48 FP694
$229.99
Time Remaining: 11h
Buy It Now for only: $298.99

Force F458015 Outboard Boat Motor Bohnalite 458015 Piston + Free Blemished Spare
Force F458015 Outboard Boat Motor Bohnalite 458015 Piston + Free Blemished Spare
$59.99
Time Remaining: 11h 9m
Buy It Now for only: $59.99

Force Chrysler outboard FA89832 Cover Exhaust Motor Leg Midsection 35 45 50 New
Force Chrysler outboard FA89832 Cover Exhaust Motor Leg Midsection 35 45 50 New
$17.50
Time Remaining: 11h 16m
Buy It Now for only: $17.50

Chrysler Force trim tab outboard motors
Chrysler Force trim tab outboard motors
$39.00
Time Remaining: 11h 20m
Buy It Now for only: $39.00

Arco Mercury Force Outboard Starter 7325
Arco Mercury Force Outboard Starter 7325
$154.01
Time Remaining: 11h 32m
Buy It Now for only: $154.01

LEG EXHAUST TUBE F694660 FORCE 1989 1994 90 150HP OUTBOARD BOAT MOTOR 704
LEG EXHAUST TUBE F694660 FORCE 1989 1994 90 150HP OUTBOARD BOAT MOTOR 704
$55.96
Time Remaining: 11h 32m
Buy It Now for only: $55.96

New Force Outboard 5hp 1998 Powerhead 800 819854A5 by Mercury Marine
New Force Outboard 5hp 1998 Powerhead 800 819854A5 by Mercury Marine
$99.99
Time Remaining: 11h 36m
Buy It Now for only: $99.99

INTAKE MANIFOLD UPPER ASSY FA440157 1988 MERCURY FORCE 125HP OUTBOARD MOTOR
INTAKE MANIFOLD UPPER ASSY FA440157 1988 MERCURY FORCE 125HP OUTBOARD MOTOR
$29.95
Time Remaining: 11h 45m
Buy It Now for only: $29.95

1990 90 hp Force Outboard Motor CYLINDER HEAD Assembly 719518
1990 90 hp Force Outboard Motor CYLINDER HEAD Assembly 719518
$55.00
Time Remaining: 11h 58m
Buy It Now for only: $55.00

1996 15 hp GAMEFISHER BY FORCE OUTBOARD
1996 15 hp GAMEFISHER BY FORCE OUTBOARD
$1,195.00
Time Remaining: 12h 1m
Buy It Now for only: $1,195.00

300 F466095 Stator 1986 Force 50hp 2 Cylinder Outboard Model 507F6A
300 F466095 Stator 1986 Force 50hp 2 Cylinder Outboard Model 507F6A
$116.97
Time Remaining: 12h 3m
Buy It Now for only: $116.97

bottom carburetor F694061 2 Force Chrysler 1989 1994 150 hp outboard motor1066
bottom carburetor F694061 2 Force Chrysler 1989 1994 150 hp outboard motor1066
$53.97
Time Remaining: 12h 5m
Buy It Now for only: $53.97

New Force Outboard 25hp Powerhead 1998 800 819240A6 by Mercury Marine
New Force Outboard 25hp Powerhead 1998 800 819240A6 by Mercury Marine
$279.99
Time Remaining: 12h 20m
Buy It Now for only: $279.99

IGNITION PLATE TERMINAL FS664358 FORCE CHRYSLER 1991 90HP OUTBOARD 704
IGNITION PLATE TERMINAL FS664358 FORCE CHRYSLER 1991 90HP OUTBOARD 704
$28.76
Time Remaining: 12h 30m
Buy It Now for only: $28.76

REED BOX ASSEMBLY 11645 MERCURY FORCE 1989 1994 70 150HP OUTBOARD 21066
REED BOX ASSEMBLY 11645 MERCURY FORCE 1989 1994 70 150HP OUTBOARD 21066
$50.95
Time Remaining: 13h 4m
Buy It Now for only: $50.95

USED MOTOR COWL COVER FS664712 1983 1989 MERCURY FORCE 125 OUTBOARD MOTOR
USED MOTOR COWL COVER FS664712 1983 1989 MERCURY FORCE 125 OUTBOARD MOTOR
$90.00
Time Remaining: 13h 5m
Buy It Now for only: $90.00

Force Outboard Hood 50 hp motor
Force Outboard Hood 50 hp motor
$59.95
Time Remaining: 13h 7m
Buy It Now for only: $59.95

125HP Force Outboard Cowl Hood Cover Lid Free Shipping
125HP Force Outboard Cowl Hood Cover Lid Free Shipping
$99.95
Time Remaining: 13h 26m

819410A3 Adapter Flange 1998 Force 50hp 2 Cylinder Outboard Serial 0E340216
819410A3 Adapter Flange 1998 Force 50hp 2 Cylinder Outboard Serial 0E340216
$40.47
Time Remaining: 13h 27m
Buy It Now for only: $40.47

REED BOX ASSEMBLY 11645 MERCURY FORCE 1989 1994 70 150HP OUTBOARD 11066
REED BOX ASSEMBLY 11645 MERCURY FORCE 1989 1994 70 150HP OUTBOARD 11066
$50.95
Time Remaining: 13h 30m
Buy It Now for only: $50.95

F178145 4 Motor Leg Cover 1987 Force 125hp 4 Cylinder Outboard Model 1254X7A
F178145 4 Motor Leg Cover 1987 Force 125hp 4 Cylinder Outboard Model 1254X7A
$80.97
Time Remaining: 13h 31m
Buy It Now for only: $80.97

Chrysler or Force outboard tiller bearing FK341816 new old stock
Chrysler or Force outboard tiller bearing FK341816 new old stock
$19.99
Time Remaining: 13h 37m
Buy It Now for only: $29.99

UPPER SHOCK MOUNT F694347 FORCE 1989 1995 90 150HP OUTBOARD BOAT MOTOR 2704
UPPER SHOCK MOUNT F694347 FORCE 1989 1995 90 150HP OUTBOARD BOAT MOTOR 2704
$49.95
Time Remaining: 13h 59m
Buy It Now for only: $49.95

817875A 1 TOP ADAPTER ASSY 1990 1994 150HP MERCURY FORCE OUTBOARD 1066
817875A 1 TOP ADAPTER ASSY 1990 1994 150HP MERCURY FORCE OUTBOARD 1066
$45.95
Time Remaining: 14h 14m
Buy It Now for only: $45.95

MERCURY quicksilver force  816514 spark control bearing block black OUTBOARD
MERCURY quicksilver force 816514 spark control bearing block black OUTBOARD
$4.99
Time Remaining: 14h 15m
Buy It Now for only: $4.99

REED BOX ASSEMBLY 11645 MERCURY FORCE 1989 1994 70 150HP OUTBOARD 41066
REED BOX ASSEMBLY 11645 MERCURY FORCE 1989 1994 70 150HP OUTBOARD 41066
$50.95
Time Remaining: 14h 22m
Buy It Now for only: $50.95

Exhaust Hose F695276 2 Force 1989 1990 85 125 hp Outboard Boat Motor Engine Part
Exhaust Hose F695276 2 Force 1989 1990 85 125 hp Outboard Boat Motor Engine Part
$27.86
Time Remaining: 14h 37m
Buy It Now for only: $27.86

1978 1991 20 25 30 35hp FORCE Chrysler outboard stator trigger F529029
1978 1991 20 25 30 35hp FORCE Chrysler outboard stator trigger F529029
$59.99
Time Remaining: 14h 54m
Buy It Now for only: $59.99

40 50 HP Force outboard starboard clamp bracket part  821774F 5
40 50 HP Force outboard starboard clamp bracket part 821774F 5
$60.00
Time Remaining: 14h 55m
Buy It Now for only: $60.00

Mercury Force outboard starter motor 40 50 HP 50 820193
Mercury Force outboard starter motor 40 50 HP 50 820193
$40.00
Time Remaining: 14h 55m
Buy It Now for only: $40.00

40 50 HP Force outboard port clamp bracket part  821773F 5
40 50 HP Force outboard port clamp bracket part 821773F 5
$60.00
Time Remaining: 14h 55m
Buy It Now for only: $60.00

HARNESS ELECTRICAL ASSEMBLY828296A 1 FOR 1997 40HP FORCE OUTBOARD
HARNESS ELECTRICAL ASSEMBLY828296A 1 FOR 1997 40HP FORCE OUTBOARD
$45.00
Time Remaining: 15h 6m
Buy It Now for only: $45.00

UPPER SHOCK MOUNT F694347 FORCE 1989 1995 90 150HP OUTBOARD BOAT MOTOR 1704
UPPER SHOCK MOUNT F694347 FORCE 1989 1995 90 150HP OUTBOARD BOAT MOTOR 1704
$49.95
Time Remaining: 15h 37m
Buy It Now for only: $49.95

3 ignition coil 7370a23 Force 1989 1995 40 153 hp outboard power head motor 681
3 ignition coil 7370a23 Force 1989 1995 40 153 hp outboard power head motor 681
$52.49
Time Remaining: 15h 45m
Buy It Now for only: $52.49

Force Outboard 40 HP Flywheel Assembly
Force Outboard 40 HP Flywheel Assembly
$55.00
Time Remaining: 15h 51m
Buy It Now for only: $55.00

Mercury 50hp 50 hp electric outboard fuel pump mariner force
Mercury 50hp 50 hp electric outboard fuel pump mariner force
$39.99
Time Remaining: 16h 12m
Buy It Now for only: $39.99


admin posted at 2011-3-19 Category: Boat Parts